Our John Deere Gator HPX 4X4 OEM Service Manual is a brand new original OEM (Original Equipment Manufacturer) manual for this machine. Tractor OEM. Find great deals for John Deere 6×4 Gator Technical Service Manual CD TMCD. Shop with confidence on eBay!. Find great deals for John Deere 4×2 / 6×4 Gator Workshop Repair Manual on CD. Shop with confidence on eBay!.
|Published (Last):||12 March 2004|
|PDF File Size:||14.90 Mb|
|ePub File Size:||17.35 Mb|
|Price:||Free* [*Free Regsitration Required]|
Use coolant with conditioner or gato conditioner to coolant before using. Coolant cannot be drawn into cooling system if suction hose is installed wrong. Bleed screw uses a special aluminum seal washer. Allow engine to cool before servicing. Change the oil more often if the vehicle is used in extreme conditions: Replace if dirt or sediment is visible on element.
Side screen must be removed for cleaning to avoid contaminating or damaging the radiator. Install new filter by turning it to the right clockwise until rubber gasket contacts filter base. Make sure deflector screen inside arrestor is not plugged or damaged:. Place a drain pan or cloth under hoses to catch any fuel that may be left in hoses. After all solution has drained, install radiator drain plug or hose and tighten engine block drain screws.
Remove and discard oil filter. Failure to check the oil level regularly could lead to serious engine problems if oil level is low: If not equipped to perform this work, see your John Deere dealer for service. Remove and discard filter element C. Oil capacities given ggator with engine and crankcase completely dry.
Fill reservoir as needed so it contains 25 – 50 mm 1 -2 in.
Allow the engine to cool before servicing. Make sure end of hose C is positioned slightly above bottom of reservoir.
John deere gator clunking noise
Damage may occur to cast aluminum parts. Built-up pressure may cause explosive release of coolant when the radiator cap is removed: Unscrew the transaxle shift lever knob.
Some oil will remain in engine after draining. Maintenance, repair, or replacement of the emission control devices and systems on this engine, which are being done at the customers expense, may be performed by any non-road engine repair establishment or individual.
Fill radiator completely with flushing solution. Remove spark plug s using appropriate spark plug socket. If engine is hard to start or runs rough, check the troubleshooting section of this manual.
John Deere 6×4 Gator Technical Service Manual CD TM1518CD
Service Engine Engine Warranty Maintenance Statement Maintenance, serbice, or replacement of the emission control devices and systems on this engine, which are being done at the customers expense, may be performed by any non-road engine repair establishment or individual. Check container label before using to be sure it has the appropriate specifications for your machine.
Add coolant mixture to reservoir so it is approximately half gaor. Remove bleed screw and seal washer A located by carburetor. Locate the fuel filter A at the front of the engine compartment. Engine exhaust system may be hot and can burn skin.
Failure to check the oil level regularly could lead to serious engine problems if oil level is low:. Loosen engine block drain screws E on right side of engine. Change the oil more often if the vehicle is used in extreme conditions:. Follow the directions on the container for correct mixture ratio. Ggator bleed screw completely and install and tighten radiator cap. The engine and veere will be hot if the engine has been running.
Carburetor is calibrated by the engine manufacturer and is not adjustable. Follow all service procedures exactly. Make sure air intake tube A is free from ceere. Certain geographical areas may require lower temperature protection.
DO NOT operate engine without air cleaner element and rubber dust unloading valve installed. Add coolant mixture at bleed screw port B until coolant runs out. Visually check dust unloading valve A. See the label on your antifreeze container or consult your John Deere dealer to obtain the latest information and recommendations. Turn radiator cap slowly to the stop to release system pressure.
John deere gator clunking noise
Fuel vapors are explosive and flammable: Using incorrect coolant mixture can damage the radiator:. Tighten bleed screw with washer halfway into bleed port. Be sure fan or flywheel screens remain installed and clean.